Đang tải... (xem toàn văn)
Hệ thống điện thân xe GD BE . Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE Hệ thống điện thân xe GD BE
GD (i30) Hệ thống điện thân xe 2012 05 Hyundai Motor Company GD Body Electrical Hệ thống mạng xe i30 GD AFLS (HME) SRS LIN Headlam p SMK TPM MDP ESC S S EPB FATC Chassis CAN PCM Multi Media CAN AMP Audi o LIN NAV I Cluster : Gateway Body CAN SJB Diagnosis Communication Line LIN Battery sensor RPAS sensor BCM GD Body Electrical Cảnh báo hệ thống kính mui Roof open Warning OFF Vehicle System GEN P GD Panorama S/roof MID EUR AUS NA P P P P DRV Door IG Timer: 7sec Warning ON (built in cluster) DRV Door Chu y: co chuong bao sunroof IG Roof close Cluster BCM Sunroof open/close status (One hardwire) Sunroo f module GD Body Electrical Hệ thống gương chiếu hậu bên Auto Folding Vehicle GD System A/folding GEN M MID M EUR M AUS M NA - Selection switch (Manual folding/Auto/Manual unfolding) SMK Door lock/unlock by RKE or Passive Folding relay Inp ut BCM Power outside mirror switch ※ Without auto position SJB Motor Unfolding relay Outside mirror puddle lamp 15se c Outside door (DRV/PAS) handle pocket lamp 15se c Motor Driver Door GD Body Electrical Hệ thống điều chỉnh độ cao tự động cho đèn pha AHLS Vehicle GD System AHLS GEN P (Automatic Headlamp Leveling System) K-Line Diagnosis Headlamp Hard Wire Leveling Headlamp device signal Vehicle speed (actuator) AUS P NA - SI-ECU (Sensor Integrated ECU) SI- te e am r Pa ad o l r wn EUR P Load free Rear ECU suspension Sensor replacement MID P PIN Description Ground Power supply - Vehicle speed (T/M) Diagnosis line Low beam On Signal Sensor output signal - GD Body Electrical Camera lùi Vehicle GD System Camera GEN P MID P EUR P AUS P NA P Location Operating condition Shift to R Clos 10se Shift to Ope c P/D/N e n IG OFF Circuit 12 V IG2 B+ Groun d Reverse S/W (M/T) Inhibitor S/W (A/T) MCU Motor Driver Operation command Motor Camera Camera power Camera ground Camera V-Out GD Body Electrical Hệ thống chìa khóa thơng minh T/Gate antenna Start button ESCL Vehicle GD Relay (ACC,IG1,IG2,ST) System ESCL GEN P MID P EUR P AUS P NA - Cluster Module External Buzzer PCM ESC Bumper antenna (1EA) Antenna (2EA) Door antenna ( 2EA) Smart key Smart key 2.5 Module GD Body Electrical Bảng táp lô ESC AFLS C-CAN Cluster B-CAN EMS EPB FATC • 256 color MICOM for graphic interface MDPS SAS TCM SVC (Super vision type) BCM • 32 bit MICOM (cluster function) ESP SMK BOX • C-CAN, B-CAN interface • Cluster with multimedia link function STD (Conventional type) • User mode setting Chassis modules• Cluster variant coding Body electrical modules • TFT/DOT LCD Compared to FD… High speed CAN (C-CAN) • Steering effort selection switch • Service maintenance alarm setting by driver • SPAS (Smart Parking Assist System) – DOM only – TFT display – DOT/SEG LCD display Low speed CAN (B-CAN) • User option: Welcome light, etc • Sound (TFT) / Buzzer (DOT) • Notice for parasitic current cut off switch status User option menu setting GD Body Electrical Nhập code cho bảng táp lô (Cluster Variant Coding) Concept Virgin cluster (Vender → Factory) Variant Coding Delivery to customer (EOL) Error symptoms Scan error Standard (94003A5070) Supervision (94023A5030) Standar d (AXXX (94003) X) GDS Checking of vehicle option Supervisi on (AXXX (94023) X) Only two variants for virgin hardware Server Generated coding inside cluster Coding Failure B100XXX EPB/MDPS… Scan error CAN signal NOT detected Coding error B100051 Coding was not performed B100XXX EPB/MDPS… Coding error CAN signal detected Process Vehicle S/W Management (CLU variant coding) Replacement (virgin cluster) IG ON + Engine Of Option (self-searching) No limit of the times for the variant coding ! GD Body Electrical Vehicle Hệ thống túi khí (Mobis_TRW) GD Depowered DAB PAB CAB, KAB,SAB PAB On/Off S/W Signal_ Crash Signal _ Deployment PAB Side Airbag Curtain Airbag Seat Belt Pretensioner Telltale Lamp (PAB On/Of Lamp) Front Impact Sensor(2) Side Impact Sensor(2) DAB GEN P P P P MID S P P P EUR S S P S AUS S S P - CHINA S S P P ACU specification - Frontal airbag : 2Squib - KAB : 1Squib - PT : 2Squib - CAB : 2Squib - SAB : 2Squib - SIS : 2EA - EDR : applied (can not read data with GDS) - EOL programming : applied - Crash output (PWM and via CAN) A/Bag Control Unit PAB DAB KAB Belt P/T 1 ACU FIS STPS - SBR PAB ON Lamp PAB OFF Lamp SIS-F SIS-R CAB FR SAB RR SAB (EU) (Except EU) 1 - 2 10 GD Body Electrical Hệ thống đèn pha tự động (AFLS) Parameter download & sensor calibration • Flat ground • Vehicle stop (engine run) • No loaded (passenger or luggage) • Headlamp Low S/W ON (‘Auto light ’ OFF) • Normal CAN communication 1 Parameter Download Check and clear DTC Sensor calibration Check and clear DTC Actuator driving Check and clear DTC Parameter download Actuato 1Level down r Swivel initialization driving Level up 3 Sensor calibration 11 .. .GD Body Electrical Hệ thống mạng xe i30 GD AFLS (HME) SRS LIN Headlam p SMK TPM MDP ESC S S EPB FATC Chassis CAN PCM... coding ! GD Body Electrical Vehicle Hệ thống túi khí (Mobis_TRW) GD Depowered DAB PAB CAB, KAB,SAB PAB On/Off S/W Signal_ Crash Signal _ Deployment PAB Side Airbag Curtain Airbag Seat Belt Pretensioner... BCM Sunroof open/close status (One hardwire) Sunroo f module GD Body Electrical Hệ thống gương chiếu hậu bên Auto Folding Vehicle GD System A/folding GEN M MID M EUR M AUS M NA - Selection switch