... addition
to this manual.
ã The Operators Manual
ã The Parts Catalog
ã Operation Manual of the Engine
ã Parts Catalog of the Engine
ã Hitachi Training Material
MANUAL COMPOSITION ... READER
ã
This manual is written for an experienced technician
to provide technical information needed to maintain
and repair this machine.
ã Be sure to thoroughly read this manual for cor-
rect ... Material
MANUAL COMPOSITION
ã
This manual consists of three portions: the Techni-
cal Manual (Operational Principle), the Technical
Manual (Troubleshooting) and the Workshop Man-
ual....
... Dispose of the used engine oil safely with
reference to “General repair procedures” in
the Reference Sections at the end of this
manual.
6 Engine oil and filter renewal
Every 6000 miles or 6 months
1ã8 ... (13.7 pints)
Transmission
4-speed manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.8 litres (4.9 pints)
5-speed manual . . . . . . . . . . . . . . ... and frequent checks are made of fluid
levels and high wear items, as suggested
throughout this manual, the engine will be
kept in relatively good running condition and
the need for additional...
... incorporated in the computer via the load potentiometer. In the event of a
fault refer to workshop repairmanual T.A. M.
POSITION OF FOOT
1
→
22
→
33
→
22
→
1
No-load (PL) 23 40 27 15
Full-load ... fitting the differential seal
B.Vi.
1058 Plug for fitting the differential seal
91755R
85965R
21-29
MANUAL GEARBOXES
Gearbox (Removal - Refitting)
21
Remove the three bolts securing the rear centre
mounting ... workshop crane securing the eyes in
place of two bolts around the gearbox.
92903S
C
engines
21-13
MANUAL GEARBOXES
Special features
GEAR CHANGE PATTERN
The gearboxes of the following types:
JB0
JB4
JB2
JB1
JB3...
... compensator
adjustment check
Replacement of compensator
Fault chart
STEERING
Axial ball joints
Manual steering box
Anti-rattle bearing on
manual steering box
Power assisted steering box
Steering box plunger
Steering ... care not
to damage the driveshaft gaiter.
Place the upper cup bolts in the appropriate holes.
A manual steering
B power steering
Tighten, to torque :
- the shock absorber lower mounting bolts ... TYRES
STEERING
MECHANICAL ELEMENT CONTROLS
77 11 190 850 NOVEMBER 1996 Edition Anglaise
"The repair methods given by the manufacturer in this document are based on the
technical specifications...
... operate?
yes
yes
no
no yes
Repair the wiring
between track B3
of connection R34
and track A1 of the
pressostat.
Repair the wiring between
track B3 of connection R34
and the fuse box.
Repair the wiring
between ... R99.
Track B4 on connector R99 and vehicle earth
M11.
yes
Repair the wiring between track A1 of
connector R99 and track 1 on relay 690.
yes
Repair the wiring between track A1 on black
connector R99 ... this is the case, remove the compressor
and check its oil level (see method in the A/C
workshop repair manual) , drain the oil in the
pipes and the condenser, change the dehydrating
bottle and adjust...
... or the trim, trim
sealing mastic part number 77 01 421 049 must be
reapplied (see "BODYWORK REPAIRS" poster).
Remove:
- the internal opening control,
- the internal door handle,
- the...