Đang tải... (xem toàn văn)
Tài liệu sửa chữa xe ô tô Renault 19 (Repair Manual) Chassis, Heating and ventilation, Sheet metal work, Sealing and Soundproofing, Trim and Upholstery
77 11 190 886NOVEMBER 1996Edition AnglaiseSealing and Soundproofing"The repair methods given by the manufacturer in this document are based on thetechnical specifications current when it was prepared.The methods may be modified as a result of changes by the manufacturer in theproduction of the various component units and accessories from which his vehiclesare constructed".All copyrights reserved by Renault.Copying or translating, in part or in full, of this document or use of the service partreference numbering system is forbidden without the prior written authority ofRenault.C Régie Nationale des Usines Renault 1988BODY SEALSWINDOW SEALS EXPLODED VIEWPRN6000 Sealing andSoundproofingPagesContentsBODY SEALSA Door pillar protective sealB "D53 CABRIOLET" windscreenpost seal6464-164-2WINDOW SEALSA Front door frame sealB Front door outer rubbing stripC Front door inner rubbing stripD Front door frame slide channelE Front door frame sealF Rear door outer rubbing stripG Rear door inner rubbing stripH Rear door frame slide channelI Quarter light outer rubbingstripJ Quarter light inner rubbing strip6666-166-166-166-266-366-366-466-466-566-5 BODY SEALSDoor pillar protective seal64A92251RThe seal is removed by destroying the clips, thenunsticking the seal using a hot air gun.NOTE: see Workshop Repair Manual M.R. 501 forfault-finding seals. SPECIAL POINTThe protective seal on the door pillar is stuck inplace and held by three clips (1) which cannot berecovered.64-1 BODY SEALSWindscreen post seal64BPRN6400Remove:- the hood strikers,- the seal.Use sealing mastic when refitting.(Using soapy water will make it easier to positionthe seal in it slides). 94819RD53CABRIOLET64-2 WINDOW SEALSFront door frame seal66A92252RLower the window to the open position.Take care as the seal is fragile.Remove the rear view mirror.Free the front section then the rear section.92253SLower the window to the open position.ATTENTION: the rubbing strip is fragile. Using anextra-flat chisel protected by a piece of cloth, raisethe rubbing strip every 10 cm.92254SRemove the internal trim.Raise the rubbing strip a shown in the diagram.Front door outer rubbing stripBFront door inner rubbing stripC66-1 WINDOW SEALSFront door frame slide channel66D92255RRemove the window.Remove the frame slide channel, starting at thevertical rear section (see diagram).PRN6600There are no particular points concerning theremoval of the inner section (1).66-2 WINDOW SEALSRear door frame seal66ERemove the trim and the small fixed windowRemove:the seal, which is very fragile, using an extra-flatchisel. Free the rear section as shown in thediagram.92257SATTENTION: the rubbing strip is fragile. Using anextra-flat chisel protected with a piece of cloth,raise the rubbing strip every 10 cm.Rear door outer rubbing stripF92256G66-3 WINDOW SEALSRear door inner rubbing strip66G92258SRemove the trim.Raise the rubbing strip as shown in the diagram.92259SRemove the window and the small fixed window.Remove the frame slide channel, starting at therear section (see diagram).Rear door frame slide channelHPRN6601There are no particular points concerning theremoval of the inner section (1).66-4 Quarter light inner rubbing stripWINDOW SEALSQuarter light outer rubbing strip66I94804RRemove the two screws (A).PRN6602JD53CABRIOLET66-5 . outer rubbingstripJ Quarter light inner rubbing strip666 6-1 6 6-1 6 6-1 6 6-2 6 6-3 6 6-3 6 6-4 6 6-4 6 6-5 6 6-5 BODY SEALSDoor pillar protective seal64A92251RThe seal. system is forbidden without the prior written authority ofRenault.C Régie Nationale des Usines Renault 198 8BODY SEALSWINDOW SEALS EXPLODED VIEWPRN6000 Sealing