Báo cáo khoa học nông nghiệp " POST HARVEST MANAGEMENT AND NEW APPROACH FOR SUPPLY CHAIN SYSTEM OF CABBAGE AND WATER MELON " doc

5 412 1
Báo cáo khoa học nông nghiệp " POST HARVEST MANAGEMENT AND NEW APPROACH FOR SUPPLY CHAIN SYSTEM OF CABBAGE AND WATER MELON " doc

Đang tải... (xem toàn văn)

Thông tin tài liệu

1 POST HARVEST MANAGEMENT AND NEW APPROACH FOR SUPPLY CHAIN SYSTEM OF CABBAGE AND WATER MELON Presenter: Nguyen Tuan Minh M.Sc. Fruit and Vegetable Research Institute, FAVRI I. Introduction Vegetables play a significant role for farmers as large number of rural household have been involved in vegetable production and trade. However, Vietnam is actually faced with a number of post-harvest problems particularly as vegetable production has been increasing fast over the last decade. The post-harvest losses are still very high with 25-30% in average due to weakness in post-harvest technology. Even with high labour inputs in vegetable production, income of farmers is still low. Profit at down-stream stages of supply chains is also low for other actors’ who are involved in distribution, transportation and trading of vegetable products. There are several possible explanation: one of them is high qualitative and quantitative losses of fresh vegetable during passage through supply chains due to lack of facilities and proper handling methods. It also causes food quality and safety problems due to the use of improper care. Post-harvest losses can occur during harvesting in the field, in packing areas, in storage, during transportation and in the wholesale and retail market. Severe losses occur because of poor facilities, lack of know-how, poor management, market dysfunction or lack of knowledge by farmers. On September 2009, long and heavy rain in Quynh Luu, Nghe An caused high spoilage rate of water melon and shorten the self life of the produce. Utilizing improved post-harvest practices (e.g. adequate harvesting, handling and treatment methods, packaging, proper transport and marketing) often results in reduced food losses, improved overall quality and food safety, and higher profits for growers and marketers. Objective: - To find out proper post-harvest management and new approach for modern supply chain for cabbage and water melon. II. Materials and research methods 1. Materials, location and timing: - Cabbage grown in Quynh Luu, Nghe An on winter-spring season in 2009 - Water melon grown in Quynh Luu, Nghe An on summer in 2009 - Chemical treatment: alum, lime, chlorine - Instruments: technical scale, tempe. loggers. 2 2. Methodology + Supply chains mapping - Cabbage and water melon delivered from Quynh Luu to Hanoi by truck, temperature loggers were put in several locations in current containers and in different position in truck. Current containers for cabbage transportation are jute bags. Some containers tested were carton with windows and wood box with soft filters. For water melon, they were put directly on floor of truck with dried straw. Tested containers were cartons with window with dried straw. + Post harvest treatment - Cabbage were treated with saturated lime and 15% alum and control - Water melon treated with chlorine solution 100 and 150ppm and control + Analysis Spoilage rate were calculated by the ration between spoilage part per total sample for cabbage, and total fruits per total sample for water melon. III. Result and discussion 3.1.Supply chain mapping for cabbage and water melon After harvesting, cabbage and water melon are often collected and transported during the night of that day by truck in order to have cool air circulation, not get in stuck. In the next early morning, commodities are at the wholesale markets or in Supermarkets in Hanoi as orders. Figure 1: Temperature mapping during the journey of cabbage from Nghe An to Hanoi Cabbages were delivered by using jute bags and put directly on truck floor. Temperature decreased gradually during transportation, from 31 0 C to 26 0 C (figure 1). Different location had 3 the same trend, but the temperature were little bit different. In general, without cool transport means, delivery at night is good way to maintain low temperature. Water melons were delivered during the night without packing containers and they were placed directly on truck floor with dried straw for filters. Similarlly, temperature decreased steadily from 32 0 C to 28 0 C(figure 2). Figure 2: Mapping temperature during journey from Nghe An to Hanoi for water melon 3.2. Spoilage rate during transportation Table 1: Spoilage of cabbage during transportation In Hanoi, spoilage rate in jute bag was the highest with 3.7% compared to 2 other containers. It is thought that cabbage in jute bag had mechanical damage due to high loading and vibration. That also caused the problem after 5 days of harvest, the spoilage in jute bag (8.6%) was twice higher than in wood box and nearly 4 time higher in carton box. Spoilage rate (%) In Hanoi After 5 days Carton used for transportation 1.1 2.2 Wood box 2.5 3.4 Jute bag (control) 3.7 8.6 4 Table 2: Spoilage rate of water melon during transportation Mechanical injury was high (3.5%) due to place water melon directly on truck floor with straw. It is believed that vibration and impact of high bulk load resulted in damage. Carton box for packing helps to reduce damage during the transportation, especially after 7 days of keeping, the spoilage rate (1.8%) occurred lower than in bulk load (6.4%). 3.3. Postharvest treatment Cabbages are often decayed in butts after harvesting. To control that spoilage, some experiments were carried out. Brush with 15% alum solution or saturated lime on the butt after trimming. Table 3: Postharvest treatment for cabbage The table 3 shows that saturated lime can control effectively the diseases. Spoilage in alum treatment (3.4%) also was much lower than in control (19.0%). Table 4: Postharvest treatment for water melon There are bacteria and fungus spores on the surface of water melon that could cause postharvest spoilage. Chlorine treatment after 10 days of harvesting reduced the spoilage rate to 0.8-1.1% while the control had high spoilage rate with 7.2%. IV. Conclusion and suggestion 1. Proper packing had a positive effect on spoilage reduction. Postharvest treatments (lime or alum for cabbage and chlorine for water melon) reduced spoilage significantly. Mechanical damage of spoilage rate (%) In Hanoi After 7 days carton 0.5 1.8 No transport packing 3.5 6.4 Spoilage (%) after 6 days Control 19.0 Alum 15% 3.4 Lime 0 Spoilage (%) after 10 days Control 7.2 Chlorine 100ppm 1.1 Chlorine 150ppm 0.8 5 2. A post harvest handbook and TOT/FFS training courses need to be taken place to upgrade knowledge of stakeholders. 3. A new approach for modern supply chain could be proposed to apply for cabbage and water melon to meet market requirement and consumer demand for higher food quality and safety: - Supply chain should be adequately simple, flexible, more direct, straightforward and well coordinated to meet the value and competitiveness of produce. - Business linkages to promote collaboration and information exchange among stakeholders. - Linkages from farm to table can be established through chain traceability systems (document system and mechanism to marking and identifying the produce records kept every step of horticultural chain in the field, packing house, suppliers, retailers…). - Each stakeholder has a defined scope, clear goals and enables the next chain member to fulfill subsequent activities. - Participants have to long-term strategic vision to change conventional methods to meet the increasing demand of consumers. - Recognize their dependence on each other and willing to work together to define common objectives, share risks and benefits and make the relationship work. - Proper handling and temperature management, speed in delivery to next stages. - A shared commitment to control produce quality and consistency. - Encourage cooperatives, contracted stakeholders to facilitate time delivery, lower risk of over production, low production cost of inputs, more knowledge to farmers thanks to share experience, better communication and technique access. - High level of confidence in each other that allows greater security in business and facilitates the development of common goals. Reference: Kanlayanarat S., R. Rolle and A. Acedo, 2009. Horticultural Chain Management for Countries of Asia and the Pacific Region/ A training package. FAO-RAP publication 2009/06. Bautista O. and E.B. Esguerra, 2007. Postharvest technology for Southeast Asian perishable Crops. 2 edition, University of the Philippines Los Banos. . sample for cabbage, and total fruits per total sample for water melon. III. Result and discussion 3.1 .Supply chain mapping for cabbage and water melon After harvesting, cabbage and water melon. 1 POST HARVEST MANAGEMENT AND NEW APPROACH FOR SUPPLY CHAIN SYSTEM OF CABBAGE AND WATER MELON Presenter: Nguyen Tuan Minh M.Sc. Fruit and Vegetable Research Institute,. Table 4: Postharvest treatment for water melon There are bacteria and fungus spores on the surface of water melon that could cause postharvest spoilage. Chlorine treatment after 10 days of harvesting

Ngày đăng: 21/06/2014, 04:20

Từ khóa liên quan

Tài liệu cùng người dùng

  • Đang cập nhật ...

Tài liệu liên quan