Đang tải... (xem toàn văn)
bộ tài liệu dành cho dân chuyên ngành ô tô cực hay về KIA FORTE cực chi tiết, cực hay. các b load miễn phí và dùng thoải mái. các bạn sử dụng chương trình đọc đuôi pdf để xem tài liệu. chúc các bạn thành công.
[...]... in the illustration - Check all clamps for deterioration or deformation; replace with the clamps new one if necessary - Add the recommended power steering fluid and bleed the power steering system Steering System > Hydraulic Power Steering System > Power Steering Oil Pump > Components and Components Location Components 9/16/2011 9:09 PM ============================================================================================================================... 28 1 Suction pipe 2 O-ring 3 Connector 4 Flow control valve 5 Flow control spring 6 O-ring 7 Cam ring 8 Oil pump cover assembly 9 Pulley Steering System > Hydraulic Power Steering System > Power Steering Oil Pump > Repair procedures Replacement 1 Drain the power steering fluid 2 Remove the drive belt 3 Remove the pressure hose from the oil pump and the suction hose from the suction pipe 9/16/2011 9:09... for excessive play (3) Check for missing needle bearing rollers 4 Others (1) Check for damage of the rack housing cylinder bore (2) Check for boot damage, cracking or aging Steering System > Hydraulic Power Steering System > Power Steering Hoses > Repair procedures Replacement - Refer to the components illustration during removal or installation - When installing, be sure to connect between hose to tube... damage B Check the surface contacting the oil seal for damage C Check the oil seal for damage 3 Check the inside of rack housing for damage 4 Check the bellows for being torn Steering System > Hydraulic Power Steering System > Power Steering Gear Box > Components and Components Location Components 9/16/2011 9:09 PM ============================================================================================================================... 20 21 Feed tube Rack housing Mounting bracket Mounting isolator Rack Oil seal Rack stopper 22 23 24 25 26 27 Bellows band Tie rod Bellows Bellows clip Lock nut Tie rod end Steering System > Hydraulic Power Steering System > Power Steering Gear Box > Repair procedures Replacement 1 Remove the front wheel & tire 9/16/2011 9:09 PM ============================================================================================================================... Bellows Bellows band Tie rod 6 Rack bar 7 Dust packing 8 Dust cap 9 Oil seal 10 Pinion plug 11 12 13 14 15 Pinion assembly Yoke plug Yoke spring Support yoke assembly Rack housing Steering System > Electric Power Steering > Steering Gear box > Repair procedures Replacement 1 Remove the front wheel & tire Tightening torque Nm (kgf.m, lb-ft): 90 ~ 110 (9.0 ~ 11.0, 65 ~ 80) 2 Disconnect the stabilizer link... removing split pin and nut 4 Loosen the bolt and then disconnect the universal joint assembly from the pinion of the steering gear box Tightening torque Nm (kgf.m, lb-ft): 30 ~ 35 (3.0 ~ 3.5, 22 ~ 25) Keep the neutral-range to prevent the damage of the clock spring inner cable when you handlethe steering 9/16/2011 9:09 PM ============================================================================================================================... removing split pin and nut 4 Loosen the bolt and then disconnect the universal joint assembly from the pinion of the steering gear box Tightening torque Nm (kgf.m, lb-ft): 30 ~ 35 (3.0 ~ 3.5, 22 ~ 25) Keep the neutral-range to prevent the damage of the clock spring inner cable when you handlethe steering wheel 5 Remove the cross member from the body by loosening the mounting bolts and nuts 9/16/2011 9:09... ============================================================================================================================ http://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenge 19 of 28 wheel 5 Remove the cross member from the body by loosening the mounting bolts and nuts 6 Remove steering gearbox from the cross member by loosening the bracket mounting bolts 7 Installation is the reverse of the removal Disassembly 1 Remove the tie rod end (B) from the tie rod (A) 9/16/2011 9:09... ============================================================================================================================ http://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenge 13 of 28 6 Remove steering gearbox from the cross member by loosening the bracket mounting bolts 7 Installation is the reverse of the removal Disassembly 1 Remove the dust packing & cap (A) from the pinion housing 9/16/2011 . FORTE/ FORTE KOUP(TD) > 2010 > G 2.0 DOHC > Steering System Steering System > General Information > Specifications Specifications Item Specification Type Manual Steering System Electric. bolt. 6. Bleed the power steering system. Steering System > Electric Power Steering > Description and Operation Description EPS (Electric power steering, Column assist type) system uses an electric. PM ============================================================================================================================== 1. Key lock assembly 2. Steering Column & EPS unit assembly 3. Universal joint assembly 4. Steering gear box Steering System > Electric Power Steering > Steering Column and Shaft